Premises and equipment

17 February 2004 by
Premises and equipment

The legal requirements concerning food premises and equipment are set out in the Food Safety (General Food Hygiene) Regulations 1995.

In addition, an employer must make sure the workplace complies with the requirements of the Workplace (Health, Safety and Welfare) Regulations 1992.

Managing premises and equipment

A proprietor of food premises can manage hygiene of premises and equipment by ensuring:

  • a system is in place where staff are trained in the principles of food hygiene
  • they follow operating procedures concerning cleaning, use and effective operation of equipment
  • equipment is on a preventative maintenance schedule.

Legal requirements - premises

The table below sets out the specific requirements with some notes on good practice and is based on information in the Catering Industry Guide to Good Hygiene Practice, published by the Chartered Institute for Environmental Health

1. Food premises must be clean and maintained in good repair and condition. Clean means visually clean. High-risk work surfaces should be cleaned at the end of each operation. Less risky surfaces, for example walls and extract ventilation, should be cleaned on a routine basis A practical way to make sure cleaning is done is to have a schedule for each area or equipment specifying when it should be done, how it should be undertaken, and who undertakes it Premises and equipment should be maintained to allow effective cleaning.
2\. The layout, design, construction and size of food premises shall: a) permit adequate cleaning and/or disinfection to protect against: - accumulation of dirt - contact with toxic materials - shedding of particles into food - formation of condensation or mould on surfaces b) permit good food hygiene practices including protection against cross-contamination between: - foodstuffs - equipment - materials and water - air supply - personnel - external sources of contamination such as pests c) provide, where necessary, suitable temperature conditions for the hygienic processing and storage of products. Construction materials should not be contaminant substances, for example, materials that would introduce a toxic substance into food. Avoid the use of material which sheds coating. Design premises to prevent the build-up of condensation. There should be sufficient space to allow high-risk food to be prepared on separate work surfaces and equipment. If this is not possible, surfaces and equipment should be cleaned and disinfected between operations. Also, it is good practice to have pest control measures designed in buildings where possible and separate waste storage areas. Air conditioning systems should be designed to ensure contaminated air is not routed into food preparation/storage rooms. Food preparation and storage rooms should have temperature controls.
3\. An adequate number of washbasins must be available, suitably located and designated for cleaning hands. An adequate number of flush lavatories must be available and connected to an effective draining system. Lavatories must not lead directly into rooms in which food is handled. What is deemed adequate depends on the size and layout of the premises. Washbasins should be used only for hand washing. In addition, they should be located near to toilet facilities. Guidance states: - It is good catering practice to site washbasins by the entrance to kitchens - There should be intervening ventilated space between toilets and food rooms - Staff and guest/customer toilets should be separate - Toilets must not open directly into a room. The Workplace (Health, Safety and Welfare) Regulations 1992 set out requirements in relation to toilets for employees.
4\. Washbasins for cleaning hands must be provided with hot and cold (or appropriately mixed) running water, materials for cleaning and hygienic drying. Where necessary, food-washing facilities must be separate from hand-washing facilities. Soap or detergent must be provided. Towels, on which the same part can be used more than once, are not recommended. A separate hand-washing basin should be provided. It is good practice to have signage indicating which basin is which.
5\. There must be suitable and sufficient means of natural or mechnical ventilation. Mechanical air flow from a contaiminated area to a clean area must be avoided. Ventilation systems must be constructed to enable filters and other parts requiring cleaning to be readily accessible. Heat and/or humidity levels should not build up to levels that could compromise the safety of food. Good practice is an ambient temperature below 25°C. Contaminated areas include waste storage and washing areas. Access can be either direct or through access panels.
6. All sanitary conveniences within food premises shall be provided with adequate natural or mechanical ventilation.Natural or mechanical ventilation should be used to prevent aerosols/odours.
7. Food premises must have adequate natural and/or artificial lighting. Lighting should allow food to be handled safely and cleaned effectively. Good practice recommends illumination levels from 150 lux in storerooms to 500 lux in preparation areas.
8. Drainage facilities must be adequate for the purpose intended, designed and constructed to avoid the risk of contamination of foodstuffs. Solid and liquid waste should flow freely away in the direction from clean to dirty areas. For example, toilets should feed into the system after the kitchen. Appliances should be connected to the drainage system with an effective trap. Inspection points must be available in the drainage system - but should be adequately sealed.
9. Adequate changing facilities for personnel must be provided where necessary. A changing area away from foods may be required, depending on the size of the operation. It is good practice to provide secure storage for personal items and a separate changing area if staff have to wear protective clothing.

Legal requirements - equipment

All articles, fittings and equipment that comes into contact with food shall be kept clean, and:

  • be in good order, repair and condition as to minimise any risk of food contamination
  • with the exception of non-returnable containers and packaging, be constructed of materials and kept in good order, repair and condition to enable them to be kept thoroughly cleaned and, where necessary, disinfected, for the purposes intended
  • be installed to allow adequate cleaning of the surrounding area.

Articles, fittings and equipment include work surfaces, food-processing equipment and utensils (crockery, glassware). Acceptable materials for equipment include:

  • stainless steel
  • food-grade plastics and laminates
  • aluminium and tinned copper

Wood is not acceptable for use with high-risk foods. Good practice recommends:

  • not using unsealed wood or galvanised equipment where open food is used
  • removing unused equipment for the premises.

Cleaning of equipment

The Supply of Machinery (Safety) Regulations 1992 include provision on hygiene structure and design. Food equipment must be designed with smooth, durable surfaces to allow effective cleaning and disinfection. Surfaces where high-risk food is handled must be disinfected. It is good practice to periodically disinfect equipment used for low-risk foods. Installation should allow for cleaning. Alternatively, equipment should be movable to enable adequate cleaning and disinfection.

The level of cleaning depends on the use of the equipment. All equipment should be cleaned regularly and so too should recently dismantled equipment. Surfaces where high-risk food has been handled should be disinfected.

by Charles Arrand Charles Arrand is an associate in the regulatory group at law firm DLA.

Disclaimer

The Caterer Breakfast Briefing Email

Start the working day with The Caterer’s free breakfast briefing email

Sign Up and manage your preferences below

Check mark icon
Thank you

You have successfully signed up for the Caterer Breakfast Briefing Email and will hear from us soon!

Jacobs Media is honoured to be the recipient of the 2020 Queen's Award for Enterprise.

The highest official awards for UK businesses since being established by royal warrant in 1965. Read more.

close

Ad Blocker detected

We have noticed you are using an adblocker and – although we support freedom of choice – we would like to ask you to enable ads on our site. They are an important revenue source which supports free access of our website's content, especially during the COVID-19 crisis.

trade tracker pixel tracking